Product ID:ENAMEL ALKYD, LUSTERLESS LOW VOC SPEC TT-E-527D BLACK 37038
MSDS Date:11/28/1995
FSC:8010
NIIN:00-297-0547
MSDS Number: BZSTX

SENTRY PAINT AND CHEMICAL CO

MILL AND LAWRENCE ST
DARBY, PA 19023
US

Emergency Phone: 800-424-9300 CHEMTREC

Info Phone: 215-522-1900

Preparer: JOHN F. BIELSKI

Cage: 34346

SENTRY PAINT AND CHEMICAL CO

DARBY, PA 19023 US

Cage: 34346

NAPHTHA, LIGHT AROMATIC (SARA 313)

CAS: 64742-95-6

Fraction By Weight: 30-35%

OSHA PEL 25 PPM

ACGIH TLV: 25 PPM

TOLUENE (SARA 313) (CERCLA)

CAS: 108-88-3

RTECS: XS5250000

Fraction By Weight: 10-15%

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

VOC = 3.14 LB/GL, 376 G/LITER

RTECS: 9999999VO

Fraction By Weight: NA

OSHA PEL NA

ACGIH TLV: NA

Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:OVEREXPOSURE WAS FOUND TO CAUSE
ANEMIA/EYE/KIDNEY DAMAGE/LIVER/CARDIAC ABNORMALITY/LUNG/SPLEEN
DAMAGE/BLOOD DISORDERS.CAUSES MUTOGENIC/REPRODUCTIVE EFFECTS IN LAB
ANIMALS.POSSIBLE EARLY-MOD CNS DEPRES SION.
GIDDINESS/HEADACHE/DIZZINESS/NAUSEA/EXTREME CASES
UNCONSCIOUSNESS/DEATH. ASPIRATION PNEUMONITIS (COUGHING*
Effects of Overexposure:*LABORED BREATHING, CYANOSIS. IN SEVERE CASES
DEATH MAY RESULT. INTENTIONAL MISUSE BY DELIBERATELY CONCENTRATING
& INHALING VAPORS MAY BE HARMFUL OR FATAL. REPORTS ASSOCIATE
CHRONIC OVEREXPOSURE W/PER MANENT BRAIN/NERVOUS SYSTEM DAMAGE.
EYES: IRRT/REDNESS/TEARING/BLURED VISION. SKIN: DERMATITIS.
BREATHING: NASAL/RESP**

First Aid:INHAL: GET TO FRESH AIR. IF BREATHING STOPS GIVE ARTIF RESP.
KEEP WARM/QUIET. GET MED AID IMMED. EYES: FLUSH W/LOTS WATER 15 MIN
OCCASIONALLY LIFTING LIDS. GET MED AID. SKIN: THOROUGHLY WASH
W/SOAP & WATER. REMOVE CONTAM CLOTHES/WASH BEFORE REUSE.
INGESTION: DON'T INDUCE VOMITING. KEEP WARM/QUIET. GET MED AID.
ASPIRATION INTO LUNGS FROM VOMITING CAN CAUSE CHEMICAL PNEUMONITIS
WHICH CAN BE FATAL.

Flash Point Method:CC
Flash Point:45.0F,7.2C
Lower Limits:0.5
Upper Limits:NONE FOUND
Extinguishing Media:CO2 OR DRY CHEMICALS FOR SMALL FIRES. FOAM FOR
LARGE FIRES. CO & CO2 ARE PRODUCTS OF COMBUSTION, USE APPROP
RESPIRATOR.
Fire Fighting Procedures:COOL CLOSED CONTAINERS W/WATER SPRAY. CLOSED
CONTAINERS MAY BUILD EXPLOSIVE PRESSURE FROM HEAT. DON'T WELD/FLAME
CUT ON/NEAR DRUM.
Unusual Fire/Explosion Hazard:VAPORS >AIR, MAY TRAVEL ALONG GROUND/MOVE
BY VENT/IGNITE BY PILET LIGHTS/FLAME/SPARK/HEATERS/SMOKING/ELEC
MOTORS/STATIC DISCHARGE/IGNIT SOURCES FAR AWAY.

Spill Release Procedures:KEEP SPECTATORS AWAY. REMOVE IGNIT SOURCES.
DIKE/CONTAIN W/INERT MAT'L (SAND/EARTH). TRANSFER LIQ TO COVERED
METAL CNTNRS FOR RECOVERY/DISPOSAL/REMOVE W/INERT ABSORBENT. USE
NONSPARKING TOOLS! PUT ABS ORBENT MAT'L IN COVERED METAL CNTNR
FORDISPOSAL.*
Neutralizing Agent:NK *DON'T CONTAM SEWERS/STREAMS/GROUND WATER
W/SPILLED MAT'L/USED ABSORBENTS.

Respiratory Protection:USE SCBA WHERE CONCENTRATIONS MAY BE ABOVE TLV
LIMITS. BELOW TLV LIMITS USE NIOSH APPROVED VAPOR RESPIRATOR.
Ventilation:LOCAL EXHAUST MUST BE SUFFICIENT TO KEEP AIRBORNE VAPOR
CONCENTRATIONS BELOW TLV.
Protective Gloves:CHEMICAL RESISTANT
Eye Protection:SAFETY GLASSES W/SIDE SHIELDS
Other Protective Equipment:EYEBATH & SAFETY SHOWER. TO PREVENT CHRONIC
SKIN CONTACT, WEAR IMPERVIOUS CLOTHING & BOOTS.
Supplemental Safety and Health
**IRRIT/DIZZINESS/WEAKNESS/NAUSEA/HEADACHE. SWALLOWING:
NAUSEA/VOMIT/DIARRHEA.INHAL/INGEST LG AMMT:
COLIC/ANEMIA/VOMIT/NEURITIS ACUTE LEAD EFFECTS: CONSTIPATION/SLEEP
DISTURBANCE/FATIGUE/HEADACHE/ANOR EXIA.

HCC:F2
Boiling Pt:B.P. Text:231 TO 335F
Melt/Freeze Pt:M.P/F.P Text:NA
Vapor Pres:<24 @ 20C
Vapor Density:>AIR @20C
Spec Gravity:1.40
pH:NA
Viscosity:77 KU
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:NEGLIGIBLE
Appearance and Odor:BLACK, HYDROCARBON ODOR
Percent Volatiles by Volume:42.8
Corrosion Rate:NA

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG ALKALIES OR AMINES.
Stability Condition to Avoid:EXCESS HEAT, SPARKS, OPEN FLAME.
Hazardous Decomposition Products:FUMES MAY CONTAIN CO & CO2.

Waste Disposal Methods:IN ACCORDANCE W/FED/STATE/LOCAL LAWS. INCINERATE
ONLY IN EPA PERMITTED FACILITY. DON'T INCINERATE CLOSED CONTAINERS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.